Results 1 to 10 of 16
Thread: Overheating at full speed
-
05-17-2015, 02:15 PM #1
Junior Member
- Join Date
- Jan 2013
- Location
- Juneau WI
- Posts
- 17
Overheating at full speed
I have had my 1999 outback ls 330 in the shop trick already this year and it my be going back if you can't help me.
I have had the impeller and the thermostat replaced but the boat still overheats at full speed.
What I'm a missing?
They say water is coming through the engine just fine. Is there other places that could be slowing the water down?
Needing help
Thanks a head of time.
Waterdog LS
-
05-17-2015, 02:46 PM #2
Junior Member
- Join Date
- Jan 2013
- Location
- Juneau WI
- Posts
- 17
Is there a filter I'm missing to check
-
05-17-2015, 03:42 PM #3
Senior Member
- Join Date
- Mar 2014
- Location
- Park City, Utah
- Posts
- 1,291
is your water pump starting to fail?
2017 Centurion Ri237
2013 Supra SA450 - Sold
2006 Mobius LSV - Sold
2004 Stingray 190LS - Sold
2016 Nissan Titan XD - Tow Rig
-
05-17-2015, 03:57 PM #4
Senior Member
- Join Date
- Jul 2002
- Location
- London Ontario Canada
- Posts
- 2,266
Check your tranny cooler for any obstruction if you dont have a water strainer
09 21v LAUNCH
99 Outback LS. Sold
run your engine after you change your oil
68 th Member. WS420,HSE Revolution, OJ 466, Acme1157,1100 sacs,Kicker HLCD's n IX500.4, Supra Coolies
1998 Response for its flat wake.
Doug
-
05-17-2015, 04:53 PM #5
Junior Member
- Join Date
- Jan 2013
- Location
- Juneau WI
- Posts
- 17
I have some one coming over to check the water pump thanks.
I don't think I have a tranny cooler.
If I do were would it be?
-
05-17-2015, 05:58 PM #6
Senior Member
- Join Date
- Mar 2003
- Location
- Springfield Missouri
- Posts
- 3,393
The tranny cooler is in line with the intake hose but if the shop says it is flowing OK then check the gauge connections. What is the gauge reading? Does it fluctuate when on plane or when it is at idle?
Originally Posted by Waterdog ls
1998 Mobius
310 HP PCM
SOLD
-
05-17-2015, 10:03 PM #7
Junior Member
- Join Date
- Jan 2013
- Location
- Juneau WI
- Posts
- 17
Water pump is bad new one comes on tuesday. Will keep you informed. Plus since the pump is off I will flush the engine in reverse to clear any possible fragments in the engine.
-
05-17-2015, 10:12 PM #8
Senior Member
- Join Date
- Mar 2003
- Location
- Springfield Missouri
- Posts
- 3,393
Interesting, mine failed a few years back but it was making a horrific noise and no temperature fluctuations. Nice that you don't need anything more than an automotive water pump.
1998 Mobius
310 HP PCM
SOLD
-
05-22-2015, 07:59 PM #9
Junior Member
- Join Date
- Jan 2013
- Location
- Juneau WI
- Posts
- 17
The water pump was bad but it still it over heating.
The tranny cooler what do to it? Flush it out replace it?
Help I'm a bout to shoot this engine
-
05-22-2015, 08:54 PM #10
Super Moderator
- Join Date
- May 2009
- Location
- North End Lake Lanier GA
- Posts
- 8,155
Shooting the engine will make it over heat.
Several things can still cause your issue.
The trans I am not sure how to flush it but I don't think the bulk of the cooling goes through it, I could be wrong though.
You said the Block flows fine, and the impeller was replaced, I assume the Impeller was whole when it was removed?
Also how do they know the block flows fine? Did they actually flow test it? I am worried you have impeller vanes stuck in it.
Also your exhaust manifolds need to be checked for flow, they clog up and this slows the water exiting and causes it to stay in the engine longer.
Is the boat only over heating under WOT? Will it cruise around the lake normally at say 20-30mph?Malo <--- Means--Evil or Mean One. This explains a lot.
2013 Mojo 2.5 Skylon Tower. Bestia < Beast >
[COLOR="#696969"]
Reply With Quote
