Results 1 to 6 of 6
-
11-30-2009, 11:42 PM #1Senior Member
- Join Date
- Jun 2008
- Location
- Eugene OR
- Posts
- 1,786
V-drive water cooling area - sticks
As you might know i have had an issue getting out the square bolts so i decided to pull the top plate. EASY. 6 bolts that a 1/2 socket fits and pulls off easy. Everyone might want to pull this off at least every other year since how it is setup it will collect junk you have sucked up. I found a few sticks in this area that could have started a bigger build up. I have attached a pic so everyone can see what it looks inside this area. Sorry for the bad pic it was taken from my cell phone. Also even with pulling both drain bolts a little water still sits in this area.
2008 Outback V - Sold but never forgotten.
“Do not wait; the time will never be “just right.” Start where you stand, and work with whatever tools you may have at your command, and better tools will be found as you go along." -Napoleon Hill
-
12-01-2009, 07:20 AM #2Senior Member
- Join Date
- Sep 2005
- Location
- Claytor Lake, VA
- Posts
- 600
I also had trouble getting the steel square drain plugs out. They were also extremely rusted. Chased the threads with a 1/4" pipe tap and installed brass hex head plugs so I can use a 9/16 socket.
Pulled my top cover last year and found some little sticks. No way to reuse the original gasket so made one out of RTV. Also replaced the bolts with anodized and anti-sieze since the originals were very rusted.
-
12-01-2009, 02:10 PM #3
Strainer?
do you two guys have a water strainer?
09 21v LAUNCH
99 Outback LS. Sold
run your engine after you change your oil
68 th Member. WS420,HSE Revolution, OJ 466, Acme1157,1100 sacs,Kicker HLCD's n IX500.4, Supra Coolies
Doug
-
12-01-2009, 05:08 PM #4Senior Member
- Join Date
- Jun 2008
- Location
- Eugene OR
- Posts
- 1,786
No strainer. Thinking of putting one in.
2008 Outback V - Sold but never forgotten.
“Do not wait; the time will never be “just right.” Start where you stand, and work with whatever tools you may have at your command, and better tools will be found as you go along." -Napoleon Hill
-
12-01-2009, 09:21 PM #5
it is cheap insurance. if have not you should probably check further up stream at the strainer in tranny fluid cooler.
2014 Mojo Surf
2013 Mojo Sold
2010 LSV Sold
2002 OB LSV Sold
-
12-14-2009, 10:59 PM #6Sled491 Guest
I put "never sieze" on everything. No problems since.