Results 1 to 8 of 8
-
07-02-2013, 12:07 PM #1
High Pitch Squeal In Gear - Dripless seal dry?
The curse continues - or maybe not if I'm lucky.
After dewinterizing, I get the boat fired up without issue. Water is pumping, everything looks good, warms right up. I gently ease it into gear and that's when it starts. High pitched squeal coming from the engine/tranny. I go into neutral, it stops. Into reverse - same high pitch squeal above the typical reverse humming tranny sound.
So I pop back into neutral and go back to inspect. Everything looks, feels fine. Good pressure, tempt. No leaks, nothing unconnected. Nothing low on fluid. Nothing hot. So I put it in gear and let it idle for about a min or so and it finally just stops squealing all of a sudden and seems normal. Quiet in and out of gear.
My suspicion is that the dripless seal was dry? Can't imagine the v-drive making that kind of noise.
I checked and the seal is getting water through the feed tube going to it. I don't see any water in the bilge.
Little nervous it may have torn and I'll have a steady leak once I drop the boat in the river/lake though...
???So when is this "old enough to know better" supposed to kick in?
2001 MobiusV - Slightly Modified...
-
07-03-2013, 02:57 PM #2
Buehler? Buehler? Anyone.....
So when is this "old enough to know better" supposed to kick in?
2001 MobiusV - Slightly Modified...
-
07-03-2013, 03:14 PM #3
Re: High Pitch Squeal In Gear - Dripless seal dry?
Water coming out from the seal outside?
PWI as usual...
-
07-03-2013, 03:28 PM #4
Too hard to tell with the fake-a-lake blasting water all over the place underneath. I don't have the fancy hose connection like you do. Yes I should - No I don't.
So when is this "old enough to know better" supposed to kick in?
2001 MobiusV - Slightly Modified...
-
07-03-2013, 04:43 PM #5
at this point i'd say you are correct, dry rubber. my answer is subject to change when its not correct
Hey, Its Moomba time
Its all about the dash - enjoy the dash, as that is your time between the dates
13 Mobius LSV-sold
08 Mobius LSV-sold
03 Mobius LSV-sold
life is about finding the balance between being a responsible adult and staying young at heart
-
07-03-2013, 08:32 PM #6
High Pitch Squeal In Gear - Dripless seal dry?
There is your problem. Running the boat in gear on dry land. The lake water lubricates your strut bushing, with the shaft turning and the strut being dry you will get all kinds of weird noise. This is why you have the button to disengage your transmission for throttling up on land
Sent from my iPhoneDavid
2017 Moomba Mojo Max Surf Edition, 2 Pair Wetsounds Rev10s powered by an SD2, 6 pair Wetsounds XS650M and Wetsounds XS12 powered by SD6 all controlled by a WS420. 2 Lumitec SeaBlaze X2 Spectrum underwater lights
SOLD***2008 Mobius LSV, Gravity III , Wake Plate, Z5, Exile SX65c's, Exile XM9s, Exile XI12D, Exile Javelin, Exile 30.2***SOLD
-
07-04-2013, 01:41 AM #7
Hopefully that's all it is. First year with the dripless seal. It was just installed last summer at the start of my season.
Every other start of the season before I have fired it up on the fake-a-lake, went into gear in the driveway, no issues, noises, etc.So when is this "old enough to know better" supposed to kick in?
2001 MobiusV - Slightly Modified...
-
07-04-2013, 12:38 PM #8
High Pitch Squeal In Gear - Dripless seal dry?
+ 2 for the dry cutlass bearing
09 21v LAUNCH
99 Outback LS. Sold
run your engine after you change your oil
68 th Member. WS420,HSE Revolution, OJ 466, Acme1157,1100 sacs,Kicker HLCD's n IX500.4, Supra Coolies
Doug